复合式直线振动流化床干燥(冷却)机是针对国内外直线振动流化床存在着漏料,返料和喷料等技术性能缺点而研制的具有国际先进水平的新型高效节能产品。1995年取得国家专利。本产品进入市场后得到国内外厂家的一致好评。根据物料的不同工艺要求,既可单独完成干燥或冷却操作,也可成为相应的专用干燥(冷却)机,诸如酒糟干燥机,矿盐,食盐干燥机及轻体物料干燥机等。
Compound Vibrating-Fluidized Dryer is a new plant of high-efficency energy save,with advanced world level.It has solved the defect of products leakage and loss which exist in many ordinary fluid bed in china and abroad.according to the different echologial requirement of materals,the plant both drying alone and drying and cooling aet finished simultaneously.
 
   1.不漏料、不返料、干燥强度高,节能30-40%。
   2.结构简单合理,外型美观,占地面积小。
   3.产量高,比一般振动流化床高35%。
   4.密封性好,对作业环境无污染,操作方便,噪音低。
Features:
   1.Material is heated uniformly,without the appearance of the products leakage and loss,high intensive drying,30-40% energy save compared with ordinery fluid beddryer.
   2.Reasonable structure desiogn,occupy little space,production to 1-8ton/d.
   3.Higher output,It is 35% higher than the ordinery fluid bed dryer.
   4.Good seal,no pollution of the environment,easy operation and low noise.
 
  湿含量<40%(湿基)的各种颗粒料状的料,例如:硼砂、硼酸、石英砂、磷石安、复合肥、活性碳、过氯乙烯、中药饮片、水丸、橡胶添加剂、矿盐、矿碴、五氯酚钠、柠檬酸、酒糟、味精、砂糖、食盐、鱼暇、种籽、粮食、薯类纤维、甜菜渣、饵料、饲料、酵母、胚芽、食品添加剂等。

Application Field:
All kinds of granular materials which water content is less 40%,such as :boricacid,borax,quartz sand,compound fertilizaer,active carbon, qerchlorve thylene,traditional chivese medicine,rubber additive,slag, citric,acid,distiller's grains,monosodium glutamate,granulated sugar, salt,seafood,seed,grain,beet slag,bait,feed,plumule and food additive ect.

 
  物料自进料口①进入机内后,在热气的作用下呈流态化完成传质传热过程去掉水分,同时在激振力场作用下逐步完成干燥的物料,做抛掷向前的连续移动。干品由排料口⑾排出。在流化床干燥机运行过程中经流化床分布板③孔眼落下的呆料落在倾斜床层(导料板)⑦上,同样做抛掷向前的连续移动,由排料口⑾排出,在压力调节阀⑤.④.⑧等器件的作用下制止了返料、喷料的发生,增加了生产能力并改善了环境污染状况。
Principle
  Materials ② is sent into dryer from the feed ①,Under the action of heat air,the materials appear fluidizdtion and finish heat transrer process,at the same time,underthe action of the vibrating,the materials are thrown up and move continously forward along the horizontal fluidized bed.the products are discharged from outlet⑾. During drying process,there are part of materials fall upon guide plate ⑦from the eyelet of distributor, ③as are thrown up and move comtinously to outlet⑾.The adjusting valve⑤and baffle plate④⑧ prevent the appearance from the products leakage and loss.
(参见系统图)

①进料口 feed
②颗粒状物料 material
③分布板 distributor
④.⑧.档板 baffle plate
⑤调节阀 adjusting valve
⑥出风口 outlet
⑦导料板 guide plate
⑨旋风分离器 cyclone
⑩引风机 fan
⑾出料口 out let
⑿气室 air chamber
⒀鼓风机(冷却用) fan
⒁振动电动机 motor
⒂进风口 inlet
⒃加热器 heater
⒄鼓风机(热风用) fan
 
版权所有© 2004 syddft.com  保留所有权利
地址:沈阳市于洪区西江街182号 联系人:贾经理 手机:18842318808
电话:024-66615603 传真:024-66615603 E-mail:syddft@163.com

 
  技术支持|蓝桥科技